TLZone Forums banner

pump

  1. Advice needed - fuel pump circuit voltage

    Suzuki TL1000R & TL1000S Forum
    My 97 TLS has never run right. It coughs and splutters and runs lumpier than a bag of spanners! Ive just stripped her down and cleaned everything, including checking all the connectors and wiring. I found that the fuel pump 10a fuse was melted so cleaned the carrier and replaced it. Ive done...
  2. Fuel Pump Issue

    Suzuki TL1000R & TL1000S Forum
    Hello all lets see if we can get the community to help . . . The fuel pump will not prime when the key is turned, therefor the bike will not run. 1997 TL1000S *Sitting for 2 years. *No issues before 2 year mark. *New battery. *Fuel pump relay replaced (didn't need to but did it anyway)...
  3. water pump seal replacement

    Suzuki TL1000R & TL1000S Forum
    This past summer I sprung a leak from the weep hole on the TLS - letting me know that the seal had failed and needed replacing - I have the old seals out and am trying to install the new water pump seal :O that lives in the engine cover case on the impeller side. This seal is housed in a...
  4. fuel pump not priming

    Suzuki TL1000R & TL1000S Forum
    Hey everyone, new guy here. I have a 1998 tlr. The fuel pump will not prime, I can jump the yellow/red and orange/ white wires at the fuel pump relay and get it to run, but the pump runs all the time and fouls the plugs on start up. I do have a code for the fuel pump circuit with the relay...
  5. GSX-R fuel pump swap.

    Suzuki TL1000R & TL1000S Forum
    I don't know if this has been covered before but if not I hope this helps. My TLS fuel pump has 52,000 plus miles on it and the tank was very rusty. So I stripped and creamed the inside of the fuel tank. I was planning on just changing the fuel pump gasket and fuel filter. I managed to find a...
  6. will a TLR water pump cover fit on a TLS

    Help Forum
    I am in the process of changing out the thermostat on my '97 TLS as I still have the original f**cked up design that Suzuki designed for the '97. I am going to go with "all stock" conversion on this job but was wondering if anyone knows if a TLR water pump cover will fit on my TLS. Thanks -
  7. k5 GSXR750 Fuel Pump work for TLR?

    Suzuki TL1000R & TL1000S Forum
    just checking this will be ok i picked one up cheap and im about to go about the custom fuel tank route to suit it i see that a few people have been running what looks to be the same pump electrically does it just plug in? it looks like it has a similar plug to what i recall seeing under the...
  8. Clutch slave cylinder and pump TLR

    Want to Buy
    Hydraulic Clutch pump without lever TLR Clutch slave cylinder TLR I want to apply a hydraulic clutch to suzuki tls i need price and shopping price to romania thx all
  9. On/Off Fuel Pump

    Help Forum
    Hey all, my fuel pump seems to be cutting for a split second while I'm riding, I've spotted the threads about this already but have a "little" problem. The bloke that had the bike before me thought it would be a "good" idea to wrap the entire loom to try waterproof it. Could someone tell me...
  10. 1999+ TLS water pump cover

    Want to Buy
    anyone got a 1999+ TLS water pump cover to sell me? 17410-02F10 on Ron Ayers web site if you need a picture. Just missed one for £23.................
  11. Tlr fuel pump gasket leak! Help

    Help Forum
    Ok hers the skinny! I bought a 98 tlr runs great never leaked from the pump at all!! Then i buy a set of fairings ant tank all fancy painted and switch the pump and gasket and it leakes like a siv!! So i take it off and put a dab of rtv gas resistant goo on it and that didnt even slow it down...
  12. Fuel pump realy help

    Help Forum
    Ok so here is where I am at. Tlr set for a few months due to a broken tappet now I have the fixed and the battey on the charger but the fuel pump won't run. I am getting the relay error code and if I jump arcoss the connector I can get the pump to work and bike run. What I am try to find out is...
  13. Why is Your Feul Pump Gasket Leaking?

    Suzuki TL1000R & TL1000S Forum
    In the Feul Pump Gasket Leaking Poll it seems that about half the folks have had or do have leaks. Is this just a product of wear/time? Or have you folks removed your feul pump gasket? Did you re-use? Did you use a new one? In other words, for the general info guy... Is it better to leave...
  14. Tlr fuel pump rubber cover thingie?????

    Help Forum
    Ok mine is old and dryrotted do i need to replace it?? Dose it serve a purpose? Can i just leave it off???:o
  15. Kit tank and pump pics.

    Bike Pictures
    I took some pics of the Yosh tank and pump today. Thought I would share some of them. Hope this works(picture-posting-virgin). Tanks been sitting up there for over three years now. All dirty! Here it is, cleaned up a little. Some pics of the bike. Yosh...
  16. Strange noise from fuel pump and no start

    Suzuki TL1000R & TL1000S Forum
    I just replaced the fuel filter with one located outside the tank, and now I have the bike back together it will not start, and the fuel pump is making a weird noise while it primes (it makes the usual high pitched whine, then halfway through priming it starts to make another whining noise that...
  17. snapped fuel pump bolt

    Suzuki TL1000R & TL1000S Forum
    Hi, I discovered my torque wrench really can't work below 10lb, and snapped a fuel pump bolt. I got the threaded part out with pliars. Has anyone had this happen to them, and where did they get a replacement bolt?
  18. TLR Fuel Pump

    Looking to Sell
    I just took this pump out as I sold the tank. It works perfectly and is in perfect condition. $125 shipped (cont. US) obo -Keith ...you know what the pump looks like but if anyone needs a pic let me know and I'll post one. :thumbup
  19. ECU can't pull in fuel pump relay?

    Suzuki TL1000R & TL1000S Forum
    I can't seem to get the ECU to pull the yellow/blue wire down to ground, thereby pulling in the fuel pump relay on my TL/S. I've verified that the relay works by swapping it with the sidestand relay. I've got 12.3 volts on the inbound orange/bl wire; but the relay doesn't pull in. Is there...
  20. Fuel Pump Gasket for 1997 TLS

    Suzuki TL1000R & TL1000S Forum
    Whats up Zone?...I have a 1997 TLS with a recalled tank which I am told is different from the stock tank. I am looking for the fuel pump gasket for this tank. If anyone can point me in the right direction or have one they would like to sell then your assistance would be greatly...
Top